oil temperature Citroen C4 2005 2.G Workshop Manual

Downloaded from www.Manualslib.com manuals search engine 10
GENERAL
Draining methods
Oil capacities are defined according to the following methods
CAPACITIES (in litres)
Draining of the engine lubrication system by GRAVITY
Place the vehicle on horizontal ground
(in the high position if
hydropneumatic suspension)
.
The engine should be hot
(oil temperature 80°C).
Drain the sump by gravity.
Remove the oil filter cartridge
(time for draining and drip-drip = 15
minutes approx.)
.
Refit the cap with a new seal.
Refit a new oil filter cartridge.
Refill the engine with oil
(see table for oil capacity).
Start the engine to fill the oil filter cartridge.
Stop the engine
(allow to stabilise for 5 minutes).Draining of the engine lubrication system by SUCTION
Place the vehicle on horizontal ground
(in the high position if
hydropneumatic suspension).
The engine should be hot (oil temperature 80°C).
Remove the oil by suction through the dipstick tube.
Remove the oil filter cartridge.
Maintain the suction of oil in the sump
(15 minutes approx.).
Refit a new oil filter cartridge.
Refill the engine with oil
(see table for oil capacity).
Start the engine to fill the oil filter cartridge.
Stop the engine
(allow to stabilise for 5 minutes).
WARNING: Remove the suction container before starting the engine.
ESSENTIAL: Systematically check the oil level using the oil dipstick.
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 10

Downloaded from www.Manualslib.com manuals search engine 11
GENERAL
C4 CAPACITIES (in litres)
1.4i 16V 1.6i 16V 2.0i 16V 2.0i 2.0i 16V
KFU NFU RFN RFJ RFK
3,75 3,25 4,25 5 5,5
1,2 1,5 1,7 1,7 1,5
2 ± 0,15 2 2
(1) (1)
With ESP = 0,85 Without ESP = 0,75
5,8 6,2 6,2 (2) - 6,6 (3) 6,2 (2) - 6,6 (3) 6,6
6,7 6,8 (2) - 6,9 (3)
0,85
60
Petrol
IMPERATIVE: Systematically check the oil level using the oil dipstick.(1) = The gearbox is lubricated for life (as a guide, the TOTAL capacity is5.85 litres after draining3 litres).
(2) = Temperature37°C. (3) = Temperature 45°C. Engine type
Oil capacity with change
of cartridge
Between Min. and Max.
Manual gearbox
Automatic gearbox
After draining
Braking circuit
Cooling circuit
Manual gearbox
Automatic gearbox
Steering electro-pump
reservoir
Fuel tank
AUTO.AUTO.
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 11

Downloaded from www.Manualslib.com manuals search engine 21
GENERAL
LUBRICANTS - TOTAL recommended oils
TOTAL ACTIVA QUARTZ
Semi-synthetic 7000 Synthetic 9000
0W40 5W30 5W40 10W40 15W50
Hot countries
Temperate countries
Cold countries Engine types
EW10J4S (CITROËN C4) X
X
X EW12J4 (CITROËN C8 2.2i 16V)
EW10A (CITROËN C4 and C5)
HDi engines with FAP (*)
Others HDi engines
SOFIM 2.8 HDi and 2.8 TDi (RELAY)
DV4 TED4 (C3 1.6 16V HDi)
Indirect injection diesel engines Petrol engines
Diesel enginesOil usage table
X
X
XX
XX
X
XX
X
XX
X
X (*)
X
XX
X
XX
X
XX
X
XX
(*) Do not use this oil in cold climatic conditions
(temperature less than - 20°C).
See the table below for the choice of TOTALengine oil grades to be used according to the climatic conditions in the country of marketing.X Others petrol engines
X
X
X
X
X
Angl.-t2-page001-39-2005 9/01/06 10:07 Page 21

Downloaded from www.Manualslib.com manuals search engine ENGINE
279
C4CHECKING THE OIL PRESSURE
Petrol Diesel
Engine type KFU NFU RFJ RFN RFK 9HX 9HY 9HZ RHR
Temperature (°C) 90° 80°
Pressure (bars) 1,5 3 1,3 1,9
Rpm1000
Pressure (bars) 3 5,6 4
Rpm 2000 2000 2000
Pressure (bars) 5 6,3
Rpm 3000 3000
Pressure (bars) 43,5
Rpm 40004000
Tools (Toolkit 4103)
2279-T.Bis X X X X X X X X X
4103-T X X X X X X X X X
(-).0710.F1 X
(-).0710.B1 X
(-).1503.JXX X
4103-T.B X X
7001-T X X X X X
4202-T X X
NOTE: The oil pressure should be checked with the engine hot, after the oil level has been checked.
Angl.-t2-page240-282-2005 9/01/06 10:16 Page 279

Downloaded from www.Manualslib.com manuals search engine 280
ENGINECHECKING THE OIL PRESSURE
To be read with the Petrol and Diesel correspondence tables
XSARA
Engine type KFW NFU RFN 8HZ 8HX WJY RHY RHZ
Temperature (°C) 90°C
Pressure (bars) 1,5 1,3 1,8 2
Rpm 1000 1000
Pressure (bars) 3
Rpm 2000
Pressure (bars) 4
Rpm 3000
Pressure (bars) 5,1 3,5 4,5 4
Rpm4000
Tools (Toolkit 4103-T)
2279-T.Bis X X X X X X X
4103-T X X X X X X X
4202-T X X X
1503-JX
3099-TX
7017-T.X23X
NOTE: The oil pressure should be checked with the engine hot, after the oil level has been checked.
XSARA
Angl.-t2-page240-282-2005 9/01/06 10:16 Page 280

Downloaded from www.Manualslib.com manuals search engine 281
ENGINE
CHECKING THE OIL PRESSURE
To be read with the Petrol and Diesel correspondence tables
XSARA PICASSO
Engine type NFV 6FZ RFN 9HZ 9HY RHY
Temperature (°C) 90°C 80°C 90°C
Pressure (bars) 3,3 1,5 1,3 2
Rpm 1000
Pressure (bars) 3
Rpm 2000
Pressure (bars) 5
Rpm 3000
Pressure (bars) 4 6,3 3,5 4
Rpm 4000 4000
Tools (Toolkit 4103-T)
2279-T.Bis X X X X X X
4103-T X X X X X X
7001-T X
4202-T X X X
1503-J X X
NOTE: The oil pressure should be checked with the engine hot, after the oil level has been checked.
XSARA PICASSO
Angl.-t2-page240-282-2005 9/01/06 10:16 Page 281